Ana içeriğe geç

16 Eylül 2016'da satışa sunulmuştur. Model 1660, 1778 GSM ya da CDMA olarak 32, 128 ya da 256 GB kapasitelerinde ve Altın Gülü, altın, gümüş, siyah ve simsiyah renklerinde satılır.

2261 Soru Tümünü görüntüle

Short on PP_VDD_Main but no heat

Hi,

I have a rare problem. Normally i fix a short in just a few minutes. But on this board i have checked several times now, without any luck.

I inject from 1 - 4.2A to the pads. Voltage down to around 0.9V, So heat should not be a problem?

I use the rosin method, removed all shields and covered the WHOLE board. Can’t find any heated component at all.

Any ideas how to proceed?

Yanıtlandı! Cevabı görüntüle Ben de bu sorunu yaşıyorum

Bu iyi bir soru mu?

Puan 0
Yorum Ekle

1 Cevap

Filtre ölçütü:
Seçilen Çözüm

That happens some times. Heat is a byproduct of power and power is the current times the voltage drop across the component. The voltage drop is determined by the resistance so if you have a very low resistance short, there will be minimal power generated, hence very little heat.

Don’t let the value on the multimeter fool you, there is always some resistance in a dead short, usually in the milliOhm range.

So consider the following:

  • If you have a 1 Ohm ( 1000 mOhms) short at 1 A, you have 1W of power being generated. If all that power is being generated through one component, you will definitely see a heat signature.
  • At the other extreme, if you have a 1 mOhm short, you now have only 0.001W of power being generated and you will not see that at all, whether you use Rosin Flux or a FLIR camera.

There is a new tool out there called the “Short Killer”. You can find on Aliexpress or eBay. It can send up to 30A into a circuit which is usually sufficient for finding difficult shorts.

Bu yanıt yardımcı oldu mu?

Puan 4

1 Yorum:

Short killer did The job, took about 1 min to find the short

tarafından

Yorum Ekle

Yanıtını ekle

Johan M sonsuza kadar minnettar olacak.
İstatistikleri Görüntüle:

Son 24 Saat: 0

Son 7 gün: 0

Son 30 gün: 1

Her zaman: 138