Ana içeriğe geç

Giriş

The cooling fan is essential for cooling the laptop’s internal components and is imperative for maintaining the performance and health of the laptop. A faulty or broken fan may result in overheating, leading to performance issues and permanent damage to the hard drive and other components. When cleaning the fan isn’t sufficient to solve the overheating problem, replacing the fan may be the only feasible alternative. This guide will show the user how to take off the back of the Vaio FS series VGRFS640 and replace the cooling fan.

  1. Turn off the laptop and disconnect any charging cables.
    • Turn off the laptop and disconnect any charging cables.

    • Flip the laptop over so that the Service Tag is shown at the top left corner.

  2. Remove the highlighted screws from the back of the laptop with a Phillips #0 Screwdriver.
    • Remove the highlighted screws from the back of the laptop with a Phillips #0 Screwdriver.

  3. Remove the highlighted screws from the panels in the bottom right-hand corner of the laptop using the Phillips #0 Screwdriver.
    • Remove the highlighted screws from the panels in the bottom right-hand corner of the laptop using the Phillips #0 Screwdriver.

  4. Remove the two panels in the bottom right-hand corner by sliding in the direction of the arrows imprinted on the panels.
    • Remove the two panels in the bottom right-hand corner by sliding in the direction of the arrows imprinted on the panels.

  5. Remove the highlighted screws underneath the removed panels using the Phillips #0 Screwdriver.
    • Remove the highlighted screws underneath the removed panels using the Phillips #0 Screwdriver.

  6. Carefully remove the hard drive from the panel in the bottom right-hand corner of the laptop.
    • Carefully remove the hard drive from the panel in the bottom right-hand corner of the laptop.

  7. Locate the battery, located on the top side of the laptop to the right of the Service Tag .
    • Locate the battery, located on the top side of the laptop to the right of the Service Tag .

    • Remove the battery by pressing inwards on the tabs on either side of the battery.

  8. Remove cover in the top left side of the laptop next to the battery by pulling it outwards.
    • Remove cover in the top left side of the laptop next to the battery by pulling it outwards.

  9. Remove the backplate of the laptop by pulling it away from the laptop.
    • Remove the backplate of the laptop by pulling it away from the laptop.

  10. Gently remove the connector for the wire running over the fan by lifting the tab on top up with your fingernail and sliding it out. Gently remove the connector for the wire running over the fan by lifting the tab on top up with your fingernail and sliding it out. Gently remove the connector for the wire running over the fan by lifting the tab on top up with your fingernail and sliding it out.
    • Gently remove the connector for the wire running over the fan by lifting the tab on top up with your fingernail and sliding it out.

  11. Unscrew the four screws securing the fan. Unscrew the four screws securing the fan.
    • Unscrew the four screws securing the fan.

  12. Gently lift out the fan. Do not forcefully pull the fan away. This may damage the circuit board.
    • Gently lift out the fan.

    • Do not forcefully pull the fan away. This may damage the circuit board.

  13. Gently disconnect the remaining wire connecting the fan to the circuit board. Gently disconnect the remaining wire connecting the fan to the circuit board.
    • Gently disconnect the remaining wire connecting the fan to the circuit board.

  14. Replace the old fan with the new one.
    • Replace the old fan with the new one.

    • Verify that the replacement fan is compatible with the computer.

    • Sony no longer has a list of compatible fans.

Sonuç

To reassemble your device, follow these instructions in reverse order.

Bir başkası bu kılavuzu tamamladı.

Geoffrey

Üyelik tarihi: 28-03-2014

252 İtibar

2 adet Kılavuz yazıldı

Takım

UMass Dartmouth, Team 2-6, Vijaybhaskar Spring 2014 UMass Dartmouth, Team 2-6, Vijaybhaskar Spring 2014 üyesi

UMASSD-VIJAYBHASKAR-S14S2G6

4 Üyeler

4 adet Kılavuz yazıldı

0 Yorum

Yorum Ekle

İstatistikleri Görüntüle:

Son 24 Saat: 0

Son 7 gün: 0

Son 30 gün: 17

Her zaman: 308